View and Download Yamaha FZ1-N service manual online. The Solution For Lost Motorcycle Coded Keys FEATURES ABS control operation The ABS. Motorcycle Yamaha FZ1-N Service Manual THEIR SAFE USE Many accidents involve inexperi- AND OPERATION ARE DEPENDENT Safe riding enced. Download Yamaha Fz1 Owners Manual Service Pdf introduction eau congratulations on your purchase of the yamaha fzs10wfzs10wc this model is.
|Genre:||Health and Food|
|Published (Last):||18 May 2009|
|PDF File Size:||2.2 Mb|
|ePub File Size:||8.30 Mb|
|Price:||Free* [*Free Regsitration Required]|
It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual should be considered a permanent part of this motorcycle and should remain with it even if the motorcycle is subsequently sold. Yamaha continually seeks advancements in product design and quality.
Therefore, while this manual contains the most current product information available at the time of printing, there may be minor discrepancies between your motorcycle and this manual. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U. Modifications made to this motorcycle other motorists can see you. Since Yamaha cannot should be kept to a minimum. Front fork compression damping force adjusting screw page 9.
Shock absorber assembly compression damping force adjusting screw page 2. Front fork rebound damping force adjusting screw page Shock absorber assembly spring preload adjusting ring page 3. Coolant reservoir page 2.
Rear brake fluid reservoir page 3. Battery page 4. Front brake fluid reservoir page 5. Radiator cap page 6. Engine oil filter cartridge page 7. Clutch lever page 9. Brake lever page 2. Left handlebar switches page Throttle grip page 3. Starter choke lever page 4.
Speedometer unit page 5. The key can be re- moved. To lock the steering 1. Do not operate the engine if it is overheated. When the tachometer displays an er- ror code, the vehicle should be checked as soon as possible in or- der to avoid engine damage. To apply the front brake, pull the lever toward the handle- bar grip.
Brake pedal The shift pedal is located on the left The brake pedal is on the right side of side of the engine and is used in com Fuel The fuel tank cap cannot be closed un- less the key is in the lock. In addition, the key cannot be removed if the cap is not properly closed and locked. Insert oners key into the seat lock, and then turn it clockwise. Push the rear of the seat down to 2. Align the appropriate groove on the ad- justing mechanism with the top of the front fork cap bolt.
To de- Never attempt to turn an adjusting This shock absorber assembly is crease the spring preload and thereby mechanism beyond the maximum or equipped with a spring ownrrs adjust Although the total number of clicks of a damping force adjusting mechanism may not exactly match the above spec- ifications due to small differences in production, the actual number of clicks always represents the entire adjusting range.
Raise the sidestand or may explode due to excessive system. Push the start switch. Does the engine start? The neutral switch may be defective. The motorcycle should not be ridden until checked by a Yamaha dealer.
YAMAHA FZ1-N SERVICE MANUAL Pdf Download.
With the engine still running: Move the sidestand up. Keep the clutch lever pulled. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused for example, as a result of exposure to the elements. Any damage, fluid leakage or loss of tire air pressure could have serious consequences. Follow the same procedure as for start- Even with the transmission in ing a cold engine with the exception the neutral position, do not that the starter choke is not required coast for long periods of time when the engine is warm.
At the recommended shift points 3. Rz1 the transmission into the neu- EAU Engine break-in shown in the following table, close tral position when the motorcycle There is never a more important period yxmaha throttle, and at the same owenrs, is almost completely stopped.
Do not park on a slope or on soft the tachometer red zone.
Yamaha FZ1-N 2007 Service Manual
If you do not have the tools or experi- ence required for a particular job, have a Yamaha dealer perform it for you. Consult a Yamaha dealer before at- tempting any changes.
From mi km or 36 months, repeat the maintenance intervals starting from mi km or 12 months. The air filter needs more frequent service if you are riding in unusually wet or dusty areas.
Refer to this section each time a panel needs to be removed and installed. Do not attempt to diagnose such 1. Spark plug cap problems yourself.
Yamaha FZ1 Owner’s Manual
Instead, have a 2. Remove the spark plug as shown, Yamaha dealer check the vehicle. Check each spark plug for elec- 2. Clean the surface of the spark plug EAU Canister for California only trode erosion and excessive car- gasket and its mating surface, and bon or other deposits, and replace then wipe off any grime from the it if necessary.
The engine oil should be between the cartridge 3. Remove the engine oil filler cap minimum and maximum level marks. Make sure that the O-ring is properly 17 Nm 1. Install the engine oil drain bolt, and 6.
Install the new oil filter cartridge then tighten it to the specified 5. Place the vehicle on the center- In order to prevent clutch slip- check the vehicle. If water has been added to the page owbers Place a container under the engine reservoir cap, add coolant to the check the antifreeze content of to collect the used coolant.
If water has been added to the Recommended antifreeze: Start the engine, and then check Remove the fuel tank bolts. Rubber cover holder 1. Before installing the fuel tank, make sure that the fuel hoses are not damaged. If any fuel hose is damaged, do not start the engine but have a Yamaha dealer replace the hose, other- 1. Air filter fx1 cover wise fuel may leak. Therefore, all carburetor adjustments should manyal left to a Yamaha dealer, who has the necessary profes- sional knowledge and experience.
Throttle cable free ownsrs The throttle cable free play should mea- sure 3. Minimum tire tread depth front and rear: This motorcycle is fitted with super- Use only the tire valves and high-speed tires. The accessories or replace- fore each ride. If any damage is ment parts you choose for your found, have a Yamaha dealer re- motorcycle should be designed spe- place the wheel. Do not attempt cifically for this model, and they Yamaha dealer check the internal clutch mechanism.
Clutch lever free play adjusting bolt 1. Distance between brake pedal and footrest 2. Clutch lever free play Rear brake light switch 2. When checking the fluid level, point that the wear indicator groove has make sure that the top of the brake almost disappeared, have a Yamaha fluid reservoir is level. Use only the recommended quality 1.
EAU Changing the brake fluid Drive chain slack ter the brake fluid reservoir when Have a Yamaha dealer change the The drive chain slack should be refilling. Water will significantly brake fluid at the intervals specified in checked before each ride and adjusted Tighten the locknuts, and then NOTE: Service the drive chain as ed if necessary.
Yamaha FZ1-N – Owner’s Manual – 98 Pages – PDF
If a cable is damaged follows. The drive chain must be lubricated Recommended lubricant: Yamaha Chain and Cable Lube or In addi- tion, the cable should be lubricated or replaced at the intervals specified in the periodic maintenance chart. If the centerstand or sidestand does push down hard on the handlebars not move up and down smoothly, several times to check if the front have a Yamaha dealer check or re- fork compresses and rebounds pair it.